05-2011, rev. 0511 www.te.com ? 2011 tyco electronics corporation, a te connectivity ltd. company datasheets and product specifcation according to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 1 schrack general purpose relays pcb relays n 2 pole 8a, 2 form c (co) or 2 form a (no) contacts n dc or ac coil n 5kv/10mm coil-contact, reinforced insulation n ambient temperature up to 85c n wg version: product in accordance to iec60335-1 n refow version: for thr (through-hole refow) soldering process typical applications boiler control, timers, garage door control, pos automation, interface modules approvals vde reg.-nr. 6106, ul e214025, ccsaus 14385 technical data of approved types on request contact data contact arrangement 2 form c (co) or 2 form a (no) rated voltage 250vac max. switching voltage 400vac rated current 8a, ul: 10a limiting continuous current 8a, ul: 10a limiting making current, max. 4s, duty factor 10% 15a breaking capacity max. 2000va contact material agni 90/10, agni 90/10 gold plated, agsno 2 frequency of operation, with/without load dc coil 360/72000h -1 ac coil 360/36000h -1 operate/release time max., dc coil 8/6ms bounce time max., dc coil, form a/form b 4/10ms electrical endurance see electrical endurance graph 1) contact ratings type contact load cycles iec 61810 rt424 dc coil c (co) 8a, 250vac, cos =1, 85c 10x10 3 rt444 ac coil a (no) 8a, 250vac, cos =1, 70c 50x10 3 rt424 ac coil c (co) 8a, 250vac, cos =1, 70c 30x10 3 ul 508 rt424 dc coil a/b (no/nc) 10a, 250vac, gen. purpose, 85c 20x10 3 rt424 dc coil a/b (no/nc) 1/2hp, 240vac, 85c 1x10 3 rt424 dc coil a/b (no/nc) pilot duty, b300, r300, 85c 6x10 3 en60947-5-1 rte24 dc coil a/b (no/nc) ac15, 250vac, 3a 6.050 rte24 dc coil a/b (no/nc) dc13, 24vdc, 2a 6.050 rte24 dc coil a/b (no/nc) dc13, 250vdc, 0.2a 6.050 en60730-1 rt424 dc coil a/b (no/nc) 6(2)a, 250vac, 85c 100x10 3 1) for refow solderable versions: actual contact performance may be infuenced by the refow soldering process. contact data (continued) mechanical endurance dc coil >30x10 6 operations dc coil, refow version >10x10 6 operations ac coil >5x10 6 operations ac coil, refow version >2x10 6 operations coil data coil voltage range, dc coil/ac coil 5 to 110vdc / 24 to 230vac operative range, iec 61810 2 coil insulation system according ul class f coil versions, dc coil coil rated operate release coil rated coil code voltage voltage voltage resistance power vdc vdc vdc ?10% 2) mw 005 5 3.5 0.5 62 403 006 6 4.2 0.6 90 400 009 9 6.3 0.9 200 400 012 12 8.4 1.2 360 400 024 24 16.8 2.4 1440 400 048 48 33.6 4.8 5520 417 060 60 42.0 6.0 8570 2) 420 110 110 77.0 11.0 28800 2) 420 2) coil resistance 12%. all fgures are given for coil without pre-energization, at ambient temperature +23c. other coil voltages on request. coil versions, ac coil 50hz coil rated operate release coil rated coil code voltage voltage voltage resistance power vac vac vac ?15% 3) va 524 24 18.0 3.6 350 3) 0.76 615 115 86.3 17.3 8100 0.76 620 120 90.0 18.0 8800 0.75 700 200 150.0 30.0 24350 0.76 730 230 172.5 34.5 32500 0.74 3) coil resistance 10%. all fgures are given for coil without pre-energization, at ambient temperature +23c, 50hz. other coil voltages on request. power pcb relay rt2 f0149-c z v b
05-2011, rev. 0511 www.te.com ? 2011 tyco electronics corporation, a te connectivity ltd. company datasheets and product specifcation according to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 2 schrack general purpose relays pcb relays power pcb relay rt2 (continued) other data (continued) terminal type pcb-tht, plug-in refow version pcb-thr mounting distance, ac coil 2.5mm weight 13g resistance to soldering heat tht, iec 60068-2-20 rtii 270c/10s rtiii 260c/5s resistance to soldering heat thr refow soldering (for refow version) forced gas convection 4) or vapour phase 5) temperature profle according en61730 packaging/unit tube/20pcs., box/500pcs. 4) infrared heating not allowed 5) recommended fuid ls/230 accessories for details see datasheet accessories industrial power relay rt note: indicated contact ratings and electrical endurance data for direct wiring of relays (according iec 61810-1); for relays mounted on sockets deratings may apply. insulation data initial dielectric strength between open contacts 1000v rms between contact and coil 5000v rms between adjacent contacts 2500v rms clearance/creepage between contact and coil 10/10mm between adjacent contacts 3/4mm material group of insulation parts iiia tracking index of relay base pti 250v refow version pti 175v other data material compliance: eu rohs/elv, china rohs, reach, halogen content refer to the product compliance support center at www.te.com/customersupport/rohssupportcenter resistance to heat and fre wg version or refow version according en60335, par30 ambient temperature dc coil -40 to 85c ac coil -40 to 70c agsno 2 contacts -40 to 70c category of environmental protection, iec 61810 standard version rtii - fux proof, rtiii - wash tight refow version rtii - fux proof vibration resistance (functional), form a/form b contact, 30 to 300hz 20g/5g shock resistance (destructive) 100g pcb layout / terminal assignment bottom view on solder pins 2 form c (co) contacts 2 form a (no) contacts s0418-ca s0163-bj s0163-bk *) with the recommended pcb hole sizes a grid pattern from 2.5 mm to 2.54 mm can be used. dimensions s0272-ba process conditions for refow soldering according to en61760-1 tht version thr version (refow solderable) s0272-bra
05-2011, rev. 0511 www.te.com ? 2011 tyco electronics corporation, a te connectivity ltd. company datasheets and product specifcation according to iec 61810-1 and to be used only together with the defnitions section. datasheets and product data is subject to the terms of the disclaimer and all chapters of the defnitions section, available at http://relays.te.com/definitions datasheets, product data, defnitions sec - tion, application notes and all specifcations are subject to change. 3 schrack general purpose relays pcb relays power pcb relay rt2 (continued) product code structure typical product code rt 4 2 4 024 type rt power pcb relay rt2 version 4 8a, pinning 5mm, fux proof e 8a, pinning 5mm, wash tight (not for refow version) contact arrangement 2 2 form c (co) contacts 4 2 form a (no) contacts contact material 3 agsno 4 agni 90/10 5 agni 90/10 gold plated coil coil code: please refer to coil versions table version blank standard version wg product in accordance with iec 60335-1 (domestic appliances) r refow solderable product code version contacts contact material coil version part number rt423730 8a, 2 form c (co) agsno 230vac standard 4-1393243-3 rT424005 pinning 5mm, contacts agni 90/10 5vdc 5-1393243-9 rt424006 fux proof 6vdc 6-1393243-1 rt424012 12vdc 6-1393243-3 rt424012wg iec60335-1 compliant 7-1415538-8 rt424024 24vdc standard 6-1393243-8 rt424024wg iec60335-1 compliant 7-1415538-7 rt424048 48vdc standard 7-1393243-0 rt424060 60vdc 7-1393243-3 rt424110 110vdc 7-1393243-5 rt424524 24vac 7-1393243-6 rt424615 115vac 7-1393243-8 rt424730 230vac 7-1393243-9 rt425003 agni 90/10 3vdc 7-1415525-1 rt425005 gold plated 5vdc 8-1393243-0 rt425012 12vdc 8-1393243-2 rt425024 24vdc 8-1393243-5 rt444012 2 form a (no) agni 90/10 12vdc 9-1393243-7 rt444024 contacts 24vdc 9-1393243-9 rte24005 8a, 2 form c (co) 5vdc 1393243-1 rte24006 pinning 5mm, contacts 6vdc 1393243-2 rte24012 wash tight 12vdc 1393243-4 rte24024 24vdc 1-1393243-0 rte24048 48vdc 1-1393243-1 rte24110 110vdc 1-1393243-4 rte24524 24vac 1-1393243-5 rte24615 115vac 1-1393243-7 rte24730 230vac 1-1393243-8 rte25005 agni 90/10 5vdc 1-1393243-9 rte25012 gold plated 12vdc 2-1393243-0 rte25024 24vdc 2-1393243-1 rte25524 2-1393243-4 rte43009 2 form a (no) agsno 9vdc 4-1415535-1 rte44009 contacts agni 90/10 3-1393243-1 rte44730 230vac 3-1393243-5 this list represents the most common types and does not show all variants covered by this datasheet. other types on request
|
